Yarmouth Boat Yard Sterndrive Service

Yarmouth Boat Yard is a certified MerCruiser Sterndrive & Engine service center. Our technicians are required to maintain their certifications on the latest products, technologies and findings. We can perform any service required to keep your sterndrive running year round. Quality maintenance or repair work done now will save you from costly repairs in the future. To complete the Winterization and Storage Contract simply download the form, then open the Adobe PDF, complete and submit. Or download, complete and save then send to service@ybyboats.com. Or simply call us at (207) 846-9050.

Customer Forms


  •  

Thinking about purchasing a new motor?

Give us a call and we can walk you through what will fit your boat best.

SPRING COMMISSIONING

  • Shrink Wrap Removal
  • Topside Cleaning
  • Topside Detailing
  • Launch Boat
  • Launch with Hydraulic Trailer
  • Lift boat or Set Back on Trailer
  • Clean & Wax Hull
  • Compound & Wax Hull
  • Safety Equipment Check
  • Fill Gas/Diesel Tanks
  • Sea Trial
  • Bottom Paint
  • Add Epoxy Barrier Coating
  • Strip Existing Bottom Paint
  • Battery Installation
  • Commission Air Conditioning
  • Air Conditioning Maintenance
  • Commission Refrigeration
  • Commission Water Systems
  • Replace Water Filter Cartridge
  • Trim Tab Maintenance
  • Commission Generator
  • Generator Preventative Maintenance
  • Vacuflush Preventive Maintenance
  • Vacuflush Vent Filter Replacement
  • Basic Mechanical Commissioning
  • Engine Tune Up
  • Computer Diagnostic Service
  • Replace Anodes / Zincs
  • Remove and Replace Engine Mounted Water Pump Impeller
  • Remove and Replace Alpha Sterndrive mounted Water Pump
  • Remove, Clean and Replace Thermostat
  • Oil and Filter Change
  • Replace Primary Fuel Filters
  • Replace High Pressure Fuel Filters
  • Compression Test
  • Replace Diesel Fuel Filters
  • Flush Cooling System
  • Replace Spark Plug Wires
  • Sterndrive Propeller Reconditioning and Shaft Straightening
  • Annual Drive Service
  • Alpha sterndrive preventive maintenance
  • Bravo sterndrive preventive maintenance
  • Volvo sterndrive preventive maintenance
  • Yanmar sterndrive preventive maintenance
  • Antifouling sterndrive
  • Antifouling transom assembly
  • Trailer check and Lube
  • Service Power Winch
  • Fill and Bleed Brake Fluid Actuator
  • Inspect Brake Pads
  • Clean, Inspect and Pack Bearings
  • Trailer storage

WINTERIZATION & PREVENTIVE MAINTENANCE

  • Treat Fuel and Run through System.
  • Run to Temp & Flush Cooling System with Fresh Water
  • Change Oil and Filter
  • Replace Fuel Filters
  • Test Permanent Antifreeze for Burst Temp
  • Drain Raw Water Cooling System & Fill with Non-toxic Antifreeze
  • Run Fogging Oil through Engine
  • Clean and Lubricate Shift & Throttle Cables
  • Clean and Lubricate Steering Cable
  • Grease Gimbal Housing Fittings
  • Remove Outdrive for Storage & Service
  • Inspect & Lubricate Gimbal Bearings
  • Check Engine Alignment
  • Clean & Lubricate the Drive Shaft Splines
  • Drain & Fill Drive Lube
  • Remove & Inspect Propeller - Clean & Grease Shaft - Check for Line
  • Replace Engine Zincs as Needed
  • Spray Engine & Electrical w/Corrosion Inhibitor

GENERAL SERVICE

  • Change Engine Oil & Filter
  • Engine Tune-Up
  • 10 hr. Service Check
  • 20 hr. Service Check
  • 100 hr. Service Check
  • Steering Cable
  • Check Electrical System
  • Adjust Throttle Shifter
  • Change Transmission Oil
  • Bilge Pump Repair
  • Lubricate Trailer Bearings
  • Rack and Pinion Stering
  • Replace Upholstery and Canvas
  • Fix Seat Slider

Questions?

Call us at (207) 846-9050, email service@ybyboats.com, or click below.

Service Appointment